2019 Dodge Charger Fuel Pump Replacement: Complete Guide to Symptoms, Cost, and What to Expect

Bottom line: If your 2019 Dodge Charger is hard to start, sputters during acceleration, or stalls unexpectedly, the fuel pump is the most likely culprit. Replacing a failing fuel pump on a 2019 Dodge Charger typically costs between $1,114 and $1,295 at a dealership, or between $1,114 and $1,229 at an independent shop, including parts and labor. The fuel pump itself is an electric unit located inside the fuel tank, and it is responsible for delivering pressurized fuel from the tank to the engine for proper combustion. Ignoring the warning signs can leave you stranded and lead to more expensive engine damage, so addressing the problem early is well worth the investment.

What Does the Fuel Pump Do in Your 2019 Dodge Charger?

The fuel pump in your 2019 Dodge Charger is an electric pump that sits inside the fuel tank. When you turn the ignition key, the pump activates and draws gasoline through a filter, pressurizes it, and sends it through the fuel lines to the engine's injectors. The pump is controlled by a relay and fuse, which ensure fuel is available during engine operation. It also incorporates a check valve that maintains residual pressure in the fuel lines, reducing startup time and preventing fuel from draining back into the tank when the engine is off. Without adequate fuel pressure, your engine cannot maintain proper combustion, leading to a range of performance issues.

Common Symptoms of a Failing Fuel Pump in Your 2019 Dodge Charger

Recognizing the warning signs of a bad fuel pump early can save you time, money, and the inconvenience of being stranded. Here are the most common symptoms to watch for:

1. Engine Sputtering or Stalling
If your Charger's engine sputters at high speeds or stalls unexpectedly, the fuel pump may not be delivering a consistent flow of fuel to the engine. This happens because the pump is unable to maintain steady pressure, causing the engine to hesitate or cut out for brief periods. Stalling is often followed by the engine restarting after a few minutes, which is a classic sign of low fuel pressure.

2. Difficulty Starting the Engine
A bad fuel pump can cause long cranking times or prevent the engine from starting altogether. When you turn the key to the "ON" position, you should hear a brief buzzing or whirring sound from the fuel tank area as the pump primes the system. If you do not hear this sound, it could indicate the pump is not working.

3. Loss of Power During Acceleration
A properly functioning fuel pump must deliver more fuel when you step on the gas pedal. If the pump is failing, it cannot keep up with the engine's increased demand, resulting in a noticeable loss of power when accelerating or climbing hills. This power loss is usually temporary at first but becomes more severe as the pump deteriorates.

4. Decreased Fuel Efficiency
When the fuel pump cannot maintain proper pressure, the engine may run rich or lean, both of which reduce fuel economy. If you notice your gas mileage dropping significantly without any other obvious cause, a failing fuel pump could be to blame.

5. Whining Noise from the Fuel Tank
A loud, high-pitched whining noise coming from the fuel tank area is often one of the first signs of a failing fuel pump. While all fuel pumps make some noise during operation, an unusually loud or high-pitched whine indicates the pump is working harder than normal and may be near failure.

2019 Dodge Charger Fuel Pump Replacement Cost Breakdown

The cost to replace the fuel pump on a 2019 Dodge Charger varies based on several factors. Here is a detailed breakdown of what you can expect to pay:

Parts Costs

  • Aftermarket fuel pump module: Typically $150 to $300
  • OEM Mopar fuel pump module: Often $350 to $500 or higher
  • For a 2019 Dodge Charger, the OEM Mopar fuel pump module kit is priced at around $357.92 MSRP, with a range from $309.97 to $357.92 depending on the specific variant.
  • Parts cost for a 2020 model (similar to 2019) is estimated at $586 to $647.

Labor Costs

  • Independent shop: Typically 2 to 4 hours at $75 to $125 per hour
  • Dealership: Often 3 to 6 hours at $120 to $180 per hour
  • Labor cost for a 2020 model (similar to 2019) is estimated at $586 to $647.

Total Estimated Costs

  • Independent shop: Roughly $1,114 to $1,229 total
  • Dealership: Roughly $1,172 to $1,295 total
  • Some sources report the average cost for a Dodge Charger fuel pump replacement between $1,284 and $1,374, or between $1,433 and $1,513.

Keep in mind that the 2019 Dodge Charger has a fuel pump located inside the fuel tank, which sits under the rear seat. Accessing the pump may require lowering the fuel tank, which adds to labor time and cost.

What Causes Fuel Pump Failure on a 2019 Dodge Charger?

Several factors can contribute to fuel pump failure. Running the fuel tank too low on a regular basis is one of the most common causes, as it allows the pump to overheat and suck in debris from the bottom of the tank. Contaminated fuel, a clogged fuel filter, and normal wear and tear over time are also frequent culprits. While the 2019 Charger is relatively new, high-mileage vehicles or those subjected to harsh driving conditions may experience premature pump failure.

How Many Fuel Pumps Does a 2019 Dodge Charger Have?

The 2019 Dodge Charger can have either one or two fuel pumps, depending on the engine and trim level. Most standard trims use a single in-tank fuel pump, while high-performance SRT Hellcat and Redeye variants use a dual-pump module. Additionally, the saddle-shaped fuel tank design means some Chargers have a secondary transfer pump to move fuel from one side of the tank to the other. Always verify your specific model year, trim, and engine configuration before purchasing replacement parts. Using your VIN is the most reliable way to ensure you get the correct fuel pump assembly.

Where to Get the Replacement Done

You have two main options for replacing your 2019 Dodge Charger's fuel pump:

Dealership Service Department

  • Pros: Technicians are factory-trained, use OEM Mopar parts, and the work comes with a manufacturer warranty.
  • Cons: Higher labor rates and parts costs, typically $1,172 to $1,295 total.

Independent Repair Shop

  • Pros: Lower labor rates, can use aftermarket parts to save money, total cost typically $1,114 to $1,229.
  • Cons: Quality of work can vary, and aftermarket parts may not match OEM quality or warranty.

DIY Considerations

Replacing a fuel pump is a challenging job that involves safety risks from stored fuel and high-pressure lines. If you lack a proper workspace, restoration equipment, and knowledge of fuel-system safety, hiring a professional is strongly advised. If you do attempt it, ensure you disconnect the battery, relieve fuel-system pressure, and follow vehicle-specific service procedures from a trusted repair manual or database.

Why Choose KEMSO for Your 2019 Dodge Charger Fuel Pump

When it comes time to replace your Charger's fuel pump, choosing the right brand makes all the difference. KEMSO Racing offers high-performance fuel pump solutions designed for Dodge Charger owners who demand reliability and durability.

KEMSO Fuel Pump Key Features:

  • High-performance construction: Built for reliable fuel delivery under demanding driving conditions, whether you are daily driving or pushing your Charger to its limits.
  • OEM replacement design: Direct fitment for your specific Charger model, eliminating the guesswork and compatibility issues that come with generic parts.
  • Lifetime warranty: KEMSO stands behind every fuel pump with a lifetime warranty, giving you peace of mind long after the installation is complete.
  • Thoroughly tested: Each pump is tested for quality and durability to ensure it meets or exceeds original equipment specifications.

KEMSO fuel pumps are designed to work with both single-pump and dual-pump configurations, depending on your Charger's specific needs. Whether you have a standard V6 Charger or a high-performance HEMI, KEMSO has a solution that fits.

Visit KEMSO Racing today to find the right fuel pump for your 2019 Dodge Charger: https://www.kemsoracing.com/

Summary

For a 2019 Dodge Charger, a fuel pump replacement typically runs from about $1,114 to $1,295, with the average cost falling near the mid-range if you use an independent shop and aftermarket parts. Dealership repairs tend to be on the higher end due to labor rates and OEM pricing. By comparing quotes, confirming part types, and understanding what work is required for your specific year and model, you can manage the cost effectively and avoid surprises at the shop. Most importantly, if you notice any of the symptoms listed above, do not delay—address the problem promptly to prevent being stranded and to avoid costly damage to other engine components.

For a reliable, high-performance replacement, visit KEMSO Racing at https://www.kemsoracing.com/


Back to blog