Hyundai Fuel Pump Recall: What You Need to Know and How to Protect Your Vehicle

If you own a 2019–2023 Hyundai or Genesis model, your vehicle may be affected by a major high-pressure fuel pump recall. The recall, issued by Hyundai Motor America and Transport Canada, affects thousands of vehicles across multiple models due to a defect in the high-pressure fuel pump (HPFP) that could cause a sudden loss of engine power while driving . This safety issue has prompted recalls in the United States, Canada, and Australia, and it is critical that owners understand the risks and take action immediately.

The Bottom Line: What the Recall Is About

The Hyundai fuel pump recall stems from a manufacturing defect in the Fuel Control Valve (FCV) inside the high-pressure fuel pump assembly. According to official recall documents from Hyundai and government safety agencies, the FCV could allow excess fuel to enter the fuel pump . This creates an overly rich air-fuel mixture, which can cause the engine to run rough, trigger the check engine light, and, in the worst case, lead to a sudden loss of drive power while driving . The safety risk is clear: a sudden loss of power increases the likelihood of a crash.

Which Vehicles Are Affected?

The recall covers a wide range of Hyundai and Genesis models. Here is the breakdown based on official recall data:

United States and Canada Recall (2024-403 / Recall 262):

  • Hyundai Elantra – 2022 and 2023 model years (N performance versions only)
  • Hyundai Kona – 2022 and 2023 model years (N performance versions only)
  • Hyundai Veloster – 2019 through 2022 model years (N performance versions only)
  • Genesis G70 – 2019 through 2023 model years

In total, 7,579 vehicles were affected in Canada alone . The U.S. recall includes the same model years and variants.

Australia Recall (REC-006573):

  • Hyundai i30N (PD) – 2017 through 2022 model years, affecting 7,293 units

New Zealand Recall (51DC01):

  • Hyundai i30 N (PDeN) – 2018 through 2024 model years
  • Kona N (OSN) – 2021 through 2022 model years

What Causes the Problem?

The defect is located in the Fuel Control Valve within the high-pressure fuel pump. Over time, the FCV can wear out, allowing an uncontrolled amount of fuel to enter the pump . When too much fuel enters the system, the engine runs rich, which can lead to:

  1. Rough engine operation – The engine may misfire or run unevenly.
  2. Check engine light illumination – The vehicle's onboard diagnostic system will detect the issue.
  3. Loss of engine power at low speeds – This is especially dangerous in stop-and-go traffic or when merging onto highways .
  4. Sudden engine stall – In some cases, the engine may shut off completely while driving .

What Should You Do If Your Vehicle Is Affected?

If you own one of the affected models, here is what you need to do:

Step 1: Check if your vehicle is included. You can visit the Hyundai recall website at www.hyundaiusa.com/campaignhome or call Hyundai Customer Care at 1-855-371-9460 (U.S.) or 1-888-216-2626 (Canada) . Have your Vehicle Identification Number (VIN) ready.

Step 2: Schedule an appointment with your Hyundai dealer. The recall remedy is being rolled out in phases. Hyundai will notify owners by mail, but you can also proactively contact your dealer. The fix involves:

  • Updating the Engine Control Module (ECM) software to better manage fuel delivery.
  • Inspecting the high-pressure fuel pump and replacing it if necessary .

Step 3: Be aware of symptoms in the interim. If you experience a reduction in drive power, engine hesitation, or the check engine light comes on, seek service immediately . Do not wait for the second recall notice.

Important: The recall repair is performed at no charge to you. Hyundai is required to fix the defect free of cost under federal safety regulations .

What Happens If You Ignore the Recall?

Ignoring a safety recall is never a good idea. In this case, the consequences are serious:

  • Increased crash risk – A sudden loss of engine power, especially at highway speeds or in heavy traffic, can lead to a collision.
  • Potential for engine damage – Running the engine with a faulty fuel pump can cause long-term damage to other components, including the fuel injectors and catalytic converter.
  • Resale value impact – A vehicle with an open recall is harder to sell and may have a lower trade-in value.

Why Hyundai Is Recalling These Vehicles Now

The recall was initiated after Hyundai identified a pattern of failures in the high-pressure fuel pump assemblies. In Australia, the recall was published in March 2026, while the U.S. and Canadian recalls were issued in July 2024 . The delay in some regions is due to the time required to develop a remedy and secure replacement parts.

Hyundai has stated that the remedy is still being prepared for certain regions, and owners will receive a second notification when parts are available . In the meantime, the company advises owners to monitor their vehicles for warning signs.

How to Prevent Future Fuel Pump Issues

While the recall addresses a specific manufacturing defect, fuel pump problems can also arise from normal wear and tear. Here are some tips to keep your fuel system in good shape:

  1. Use high-quality fuel – Low-quality gasoline can contain contaminants that damage the fuel pump.
  2. Keep your fuel tank at least a quarter full – Running the tank low can cause the pump to overheat and suck in debris from the bottom of the tank.
  3. Replace the fuel filter regularly – A clogged filter puts extra strain on the fuel pump.
  4. Pay attention to warning signs – If you hear a whining noise from the fuel tank, experience hard starting, or notice a loss of power, have the fuel system checked.

If You Need a Replacement Fuel Pump: Why KEMSO Is the Right Choice

If your Hyundai fuel pump fails—whether due to the recall issue or general wear and tear—you need a replacement that is reliable, high-performance, and built to last. That is where KEMSO Fuel Pumps come in.

KEMSO is a trusted brand that specializes in high-performance, OEM replacement fuel pumps for a wide range of vehicles, including cars, motorcycles, ATVs, and watercraft. Every KEMSO pump is designed to be a direct OEM replacement for your stock fuel pump, meaning it fits perfectly and installs easily . Compared to the original equipment, KEMSO pumps deliver over 20% more flow at 43 psi, which means better fuel delivery and improved engine performance .

Here is what makes KEMSO stand out:

1. Superior Performance
KEMSO fuel pumps are built for both daily drivers and high-performance applications. They support up to 200 liters per hour (LPH) at 43 psi, significantly surpassing the original flow rate of 60–80 LPH . This extra flow capacity ensures your engine gets the fuel it needs, even under heavy load.

2. Lifetime Warranty
KEMSO stands behind the quality of its products. Every KEMSO fuel pump comes with a lifetime warranty, giving you peace of mind that your investment is protected . The serialized pump body guarantees that your pump is genuine and covered.

3. OEM Replacement Made Easy
The kit includes everything you need for a hassle-free installation: the pump itself, gradient density fuel strainers, flex hoses, tank seals, wiring connectors, and more . KEMSO pumps are designed to work with both gasoline and E85 ethanol fuel, making them versatile for any application .

4. Unmatched Quality Control
Unlike cheap aftermarket parts, KEMSO has a rigorous Quality Control Program (ISO/TSO). Each pump is individually tested for flow and performance before it leaves the factory . This means you are getting a product that is reliable and built to last.

5. Trusted by Enthusiasts and Professionals
KEMSO fuel pumps are used by vehicle owners who demand the best. Whether you own a Hyundai, Honda, Kawasaki, Ducati, KTM, or Sea-Doo, KEMSO has a pump that fits your vehicle . The brand is known for its commitment to quality and customer satisfaction.

If you are looking for a replacement fuel pump for your Hyundai or any other vehicle, visit KEMSO Racing today to find the right pump for your model. With a lifetime warranty, superior performance, and easy installation, KEMSO is the smart choice for keeping your vehicle on the road.

Visit KEMSO Racing now: https://www.kemsoracing.com/

Final Thoughts

The Hyundai fuel pump recall is a serious safety issue that affects thousands of drivers. If your vehicle is included, do not delay—contact your Hyundai dealer and schedule the repair. In the meantime, watch for warning signs like engine hesitation or a check engine light.

And if you ever need a replacement fuel pump, whether for a recall-related repair or a general upgrade, choose a brand you can trust. KEMSO Fuel Pumps offer the performance, reliability, and warranty coverage that give you confidence on the road.

For more information and to browse KEMSO's full product line, visit: https://www.kemsoracing.com/


Back to blog